{"product_id":"eureka-nec180-pro-replacement-battery-252v-2000mah-li-ion","title":"Eureka NEC180 Pro Replacement Battery 25.2V 2000mAh BP25220F","description":"\u003cdiv class=\"bpw-desc\"\u003e\n  \u003ch2 class=\"bpw-desc-h2\"\u003eEureka NEC180 Pro — 25.2V Li-ion Replacement Battery (BP25220F)\u003c\/h2\u003e\n\n  \u003cp class=\"bpw-desc-lead\"\u003eThis is a 25.2V lithium-ion replacement battery for the Eureka NEC180 Pro cordless stick vacuum. It carries a 2000mAh (50.4Wh) capacity and slots into the original battery bay using the same connector and BMS communication protocol as the factory unit. When the original cell degrades and suction drops off well before the indicator hits low, this is the direct swap.\u003c\/p\u003e\n\n  \u003cul class=\"bpw-desc-bullets\"\u003e\n    \u003cli\u003e\n\u003cstrong\u003eNEC180 Pro fitment:\u003c\/strong\u003e\n    The NEC180 Pro runs a 25.2V six-cell lithium pack with a BMS that monitors individual cell voltage and communicates state-of-charge to the vacuum's motor controller. The BP25220F matches that voltage rail and connector pinout exactly — the motor controller recognises the pack on first insertion without any recalibration step.\u003c\/li\u003e\n\n    \u003cli\u003e\n\u003cstrong\u003eBench tested on actual hardware:\u003c\/strong\u003e\n    We cycled this pack through full charge and sustained-draw discharge runs. The BMS held cell balance across all six cells and triggered overcurrent protection cleanly when we simulated a filter-restriction load spike — no false trips under normal suction cycles.\u003c\/li\u003e\n\n    \u003cli\u003e\n\u003cstrong\u003eDock charging habit on the NEC180 Pro:\u003c\/strong\u003e\n    Do not leave this vacuum sitting on the charging dock permanently. The NEC180 Pro dock delivers a continuous trickle once the pack is full, and sustained trickle current accelerates capacity fade in lithium cells faster than regular charge-and-remove cycling. Charge fully, then pull the vacuum off the dock.\u003c\/li\u003e\n  \u003c\/ul\u003e\n\n  \u003chr class=\"bpw-desc-divider\"\u003e\n\n  \u003ch3 class=\"bpw-desc-h3\"\u003eSuction dropping before the battery indicator reaches low on the NEC180 Pro\u003c\/h3\u003e\n\n  \u003cp class=\"bpw-desc-p\"\u003eThis happens because a partially blocked filter forces the motor to draw significantly more current than rated to maintain airflow. The BMS reads that elevated current draw and begins throttling output voltage to protect the cells — the motor slows, suction drops, and the battery indicator still shows mid-range because state-of-charge hasn't dropped yet. A degraded original cell compounds this because aged cells show higher internal resistance, causing voltage sag under load even at 50–60% charge. Clean or replace the filter first, then swap the battery if sag persists. A healthy pack under normal filter conditions holds above 23V under load.\u003c\/p\u003e\n\n  \u003ch3 class=\"bpw-desc-h3\"\u003eMotor cuts out mid-clean then recovers after a short pause\u003c\/h3\u003e\n  \u003cp class=\"bpw-desc-p\"\u003eThis is a BMS overcurrent trip, not a motor fault. When suction path restriction — blocked filter, tangled brush roll, or debris blockage — causes motor current to spike past the BMS threshold, the pack shuts output off to protect the cells. Removing load for 30–60 seconds lets the BMS reset and the vacuum restarts. The cut-outs will keep recurring until the restriction is cleared. Check the filter and brush roll first; if the motor cuts out again on a clean, unrestricted path, measure pack voltage immediately after restart — below 22V under light load points to a degraded cell that needs replacing.\u003c\/p\u003e\n\u003c\/div\u003e","brand":"BatteryWeb","offers":[{"title":"Warranty 1 Year","offer_id":43428001972314,"sku":"BWCS-ERC180VX-1","price":69.99,"currency_code":"USD","in_stock":true},{"title":"Warranty 2 Year","offer_id":43428002005082,"sku":"BWCS-ERC180VX-2","price":80.99,"currency_code":"USD","in_stock":true},{"title":"Warranty 3 Year","offer_id":43428002037850,"sku":"BWCS-ERC180VX-3","price":88.99,"currency_code":"USD","in_stock":true}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0674\/4775\/0746\/files\/BW-CS-ERC180VX-1.webp?v=1779933799","url":"https:\/\/batteryweb.com\/products\/eureka-nec180-pro-replacement-battery-252v-2000mah-li-ion","provider":"BatteryWeb","version":"1.0","type":"link"}