{"product_id":"leica-cs07-replacement-battery-74v-2600mah-li-ion","title":"Leica GEB223 CS07 Replacement Battery 7.4V 2600mAh","description":"\u003cdiv class=\"bpw-desc\"\u003e\n  \u003ch2 class=\"bpw-desc-h2\"\u003eLeica CS07 — 7.4V Li-ion Replacement Battery (GEB223)\u003c\/h2\u003e\n\n  \u003cp class=\"bpw-desc-lead\"\u003eThe GEB223 is a 7.4V, 2600mAh Li-ion battery for the Leica CS07 field controller used in robotic total station workflows. It slots directly into the CS07 battery bay and uses the same connector and BMS handshake as the original Leica cell. Voltage and capacity match OEM specification exactly — 7.4V nominal, 19.24Wh.\u003c\/p\u003e\n\n  \u003cul class=\"bpw-desc-bullets\"\u003e\n    \u003cli\u003e\n\u003cstrong\u003eCS07 field controller fit:\u003c\/strong\u003e\n    The CS07 runs a 7.4V power rail with a BMS handshake that validates cell chemistry and voltage at startup. This replacement uses matched Li-ion cells and carries the correct BMS profile, so the controller reads the pack normally rather than flagging an incompatible or unrecognised battery.\u003c\/li\u003e\n\n    \u003cli\u003e\n\u003cstrong\u003eBench tested on actual hardware:\u003c\/strong\u003e\n    We cycled this pack under sustained sensor and communication loads typical of total station field work. The BMS held voltage within spec across the draw profile and did not trip a premature cutoff during GPS or radio module polling.\u003c\/li\u003e\n\n    \u003cli\u003e\n\u003cstrong\u003eFirst-use calibration on the CS07:\u003c\/strong\u003e\n    After installing this pack, run a full calibration cycle through the CS07 instrument menu before field deployment. The CS07 maps battery state during that calibration pass, and skipping it causes the low-battery warning to fire early — often mid-session — on the first measurement run.\u003c\/li\u003e\n  \u003c\/ul\u003e\n\n  \u003chr class=\"bpw-desc-divider\"\u003e\n\n  \u003ch3 class=\"bpw-desc-h3\"\u003eBMS lockout after the CS07 sat unused in a carry case for months\u003c\/h3\u003e\n  \u003cp class=\"bpw-desc-p\"\u003eLi-ion cells self-discharge slowly during storage. If the CS07 sits in a case for several months with the battery installed, the pack can drop below the BMS recovery threshold — typically around 2.5V per cell. At that point the BMS enters a protection lockout and the charger will not initiate a charge cycle at all. The fix is a slow-recovery charge using a charger that supports a pre-charge or trickle mode below 3.0V per cell. Once cell voltage climbs above the recovery threshold, the BMS releases the lockout and normal charging resumes. If the pack was stored separately, check cell voltage with a multimeter — anything below 5.0V across both cells combined needs a trickle recovery pass before full charging.\u003c\/p\u003e\n\n  \u003ch3 class=\"bpw-desc-h3\"\u003eCS07 display showing an inconsistent battery percentage after a reboot\u003c\/h3\u003e\n  \u003cp class=\"bpw-desc-p\"\u003eThe CS07 estimates remaining charge by reading cell voltage and comparing it against a threshold table calibrated to the original battery. A new cell has a slightly different discharge curve than an aged OEM pack, so the percentage shown at reboot can read high or low until the instrument recalibrates. Run two or three full discharge-and-charge cycles through the instrument before trusting the percentage indicator in the field. After those cycles the CS07 maps the new cell's voltage-to-capacity curve and the readout stabilises. If the display still jumps after three cycles, verify resting cell voltage with a multimeter — a healthy fully charged pack reads 8.3–8.4V across the terminals.\u003c\/p\u003e\n\u003c\/div\u003e","brand":"BatteryWeb","offers":[{"title":"Warranty 1 Year","offer_id":43360516341850,"sku":"BWCS-TOX110SL-1","price":67.99,"currency_code":"USD","in_stock":true},{"title":"Warranty 2 Year","offer_id":43360516374618,"sku":"BWCS-TOX110SL-2","price":79.99,"currency_code":"USD","in_stock":true},{"title":"Warranty 3 Year","offer_id":43360516407386,"sku":"BWCS-TOX110SL-3","price":88.99,"currency_code":"USD","in_stock":true}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0674\/4775\/0746\/files\/BW-CS-TOX110SL-1.webp?v=1778615963","url":"https:\/\/batteryweb.com\/products\/leica-cs07-replacement-battery-74v-2600mah-li-ion","provider":"BatteryWeb","version":"1.0","type":"link"}