{"product_id":"zcs-tech-d5-replacement-battery-252v-10200mah-li-ion","title":"ZCS Tech D5 Cordless Lawn Mower Replacement Battery 25.2V 10200mAh","description":"\u003cdiv class=\"bpw-desc\"\u003e\n  \u003ch2 class=\"bpw-desc-h2\"\u003eZCS Tech D5 \/ D7 \/ D20 — 25.2V Li-ion Replacement Battery\u003c\/h2\u003e\n\n  \u003cp class=\"bpw-desc-lead\"\u003eThis 25.2V, 10200mAh (257.04Wh) lithium-ion battery replaces the original pack on ZCS Tech D5, D7, and D20 cordless lawn mowers. It uses the same cell count and voltage rail as the factory battery, so the charger and BMS handshake remain intact. Capacity figure is taken directly from product data — not extrapolated.\u003c\/p\u003e\n\n  \u003cul class=\"bpw-desc-bullets\"\u003e\n    \u003cli\u003e\n\u003cstrong\u003eD5, D7, and D20 platform compatibility:\u003c\/strong\u003e\n    All three models share a 25.2V nominal voltage rail and the same battery bay geometry. The BMS communication protocol is consistent across the series, so the charger accepts this pack without throwing a fault on any of the three models.\u003c\/li\u003e\n\n    \u003cli\u003e\n\u003cstrong\u003eBench tested on actual hardware:\u003c\/strong\u003e\n    We ran this pack through full charge and load cycles on a D-series mower. The BMS held cutoff thresholds correctly under simulated blade-motor inrush, and cell balancing completed normally at the top of charge.\u003c\/li\u003e\n\n    \u003cli\u003e\n\u003cstrong\u003eSeasonal storage tip:\u003c\/strong\u003e\n    If the mower sits through winter, remove the battery and store it at around 50% charge — not flat. A fully discharged pack left for months can drop below the BMS re-acceptance voltage, and the charger will refuse to initialise the pack in spring.\u003c\/li\u003e\n  \u003c\/ul\u003e\n\n  \u003chr class=\"bpw-desc-divider\"\u003e\n\n  \u003ch3 class=\"bpw-desc-h3\"\u003eBMS cutoff on thick-grass and wet-grass blade load\u003c\/h3\u003e\n  \u003cp class=\"bpw-desc-p\"\u003eThe D-series blade motor draws a sharp inrush current every time it bites into dense or wet grass. If that spike exceeds the BMS overcurrent threshold — around 30A on this cell configuration — the pack cuts out to protect the cells. This is not a battery fault; it is the BMS doing exactly what it should. Let the mower sit for 60 seconds, then resume at a slightly faster walking pace so the blade clears the grass in one pass rather than stalling in it. If cutouts happen repeatedly on dry, short grass, check the blade for debris restricting free spin.\u003c\/p\u003e\n\n  \u003ch3 class=\"bpw-desc-h3\"\u003eCharger shows fault light after the mower sat all winter\u003c\/h3\u003e\n  \u003cp class=\"bpw-desc-p\"\u003eLi-ion cells self-discharge slowly over months. If the pack sat fully depleted in a cold garage, the cell voltage may have dropped below 2.5V per cell — the threshold below which most chargers will not begin a charge cycle. Connect the charger and leave it for 15–20 minutes without interruption; some chargers run a trickle pre-charge to bring cells back above the 2.5V acceptance floor before switching to full charge. If the fault light stays on after 20 minutes, measure pack voltage at the terminals — anything below 20V total across the 6S configuration means one or more cells have dropped too far to recover safely.\u003c\/p\u003e\n\u003c\/div\u003e","brand":"BatteryWeb","offers":[{"title":"Warranty 1 Year","offer_id":43381308424282,"sku":"BWCS-ABL120VX-1","price":229.99,"currency_code":"USD","in_stock":true},{"title":"Warranty 2 Year","offer_id":43381308457050,"sku":"BWCS-ABL120VX-2","price":273.99,"currency_code":"USD","in_stock":true},{"title":"Warranty 3 Year","offer_id":43381308489818,"sku":"BWCS-ABL120VX-3","price":305.99,"currency_code":"USD","in_stock":true}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0674\/4775\/0746\/files\/BW-CS-ABL120VX-1.webp?v=1778899944","url":"https:\/\/batteryweb.com\/products\/zcs-tech-d5-replacement-battery-252v-10200mah-li-ion","provider":"BatteryWeb","version":"1.0","type":"link"}